South Houston, TX Solar Panel Removal and Reinstallation for Roof Work
Storm damage or an aging roof under your panels means the array has to come off. Done right, the panels go back on a sound roof that will last.
Schedule Your Roofing Inspection Today
Fill out the information below and we’ll reach out to complete your estimate as soon as possible!
How the job works
Check and photograph
The array and the roof are inspected and photographed so everyone knows their condition before work begins.
Take the panels down
Panels and racking are removed carefully and stored safely during the roof work.
Repair or replace the roof
Shingles, underlayment and decking under the array are fixed. See roof repair in South Houston for smaller jobs.
Flash the mounts
Mount points are sealed into the new roof surface, not set over old holes.
Put the panels back
The array goes back in its layout and is checked before the job closes.
Why it comes up often in South Houston
NOAA's Storm Prediction Center logged 32 hail reports within 10 miles of South Houston from 2015 through 2024, all in 2019, 2023 and 2024. The largest was 2 inches, on June 23, 2023. Roofs with panels that went through those storms may have damage around and under the array that cannot be reached with the panels in place.
Age is the other reason. Half of the homes in South Houston were built before 1969 (U.S. Census Bureau, American Community Survey 2020-2024). On houses that old, a roof under an array may need decking repairs or a full tear-off, and both require the panels to come off first.
Leaks under an array are especially sneaky on old houses. Water can enter at a mount, run along old plank decking and appear on a ceiling far from the panels. Patching from above without lifting them usually misses the real entry point. Our guide on why roof damage may not cause an immediate leak explains why problems under panels can sit unnoticed for months.
Signs the roof under your panels needs work
A ceiling stain in a room below the array.
Water dripping near a mount after rain.
Granules collecting in gutters under the panels.
Curling or cracked shingles at the edges of the array.
Hail damage on the rest of the roof after a storm.
A roof that is old enough to be due for replacement.
Mounts or rails that look loose, rusted or out of line.
Planning tips
One estimate
Have the roof work and the panel work priced together so nothing is left out.
Storage
Ask where panels will be kept and how they are protected while off the roof.
Records
Photos of each panel before removal show its condition at the start.
Insurance
If hail started it, read our roof insurance claims page. Coverage depends on your policy and your insurer.
Timing
Read how long a roof replacement takes in Texas to plan the whole project.
Weather window
The roof sits open while panels are off, so plan the work for a stretch with steadier weather when you can.
One team for roof and panels
When one company handles both the roof and the panels, there is a single schedule and no question about who is responsible for the mounts. GemSco does roofing and solar panel removal and reinstallation, and we are family owned, fully licensed and insured, with 20+ years of experience. Estimates are free. Visit our solar panel removal and reinstallation page or see what we do in South Houston.
Frequently Asked Questions
Can a leak under solar panels be fixed without removing them?
Sometimes, if the leak is at the edge of the array and easy to reach. A leak coming from under the panels usually cannot be traced or repaired properly without lifting them. Patching around them often misses the real entry point, and the leak comes back with the next rain.
Will removing panels damage them?
Careful handling and safe storage keep the risk low. Photos taken before removal record each panel's condition, so any existing cracks or defects are documented. That way you know whether a problem was there before the job or came up during it.
Should I replace the whole roof if only part is under the panels?
It depends on the condition of the whole roof. If the shingles outside the array are worn or hail damaged too, replacing everything at once avoids a second round of panel removal later. If only the area under the panels is bad, a section repair can be enough.
More Roofing Help in South Houston
Roofing in South Houston, TX
City overviewRoof Repair in South Houston
Learn MoreRoof Replacement in South Houston
Learn MoreStorm & Hail Damage in South Houston
Learn MoreRoof Inspection in South Houston
Learn MoreCommercial Roofing in South Houston
Learn MoreGutters in South Houston
Learn MoreSolar Panel Installation in South Houston
Learn MoreSolar Removal & Reinstall Near South Houston
Solar Removal & Reinstall in Pasadena, TX
Learn MoreSolar Removal & Reinstall in Galena Park, TX
Learn MoreSolar Removal & Reinstall in Deer Park, TX
Learn MoreSolar Removal & Reinstall in Jacinto City, TX
Learn MoreSolar Removal & Reinstall in Pearland, TX
Learn MoreSolar Removal & Reinstall in La Porte, TX
Learn MoreWe’re Here to Help!
GemSco Roofing & Solar serves Houston, DFW, Austin, San Antonio and surrounding areas. We’re family owned and fully licensed and insured.