Solar Panel Removal and Reinstallation in Galena Park
Roof damage under solar panels cannot be fixed with the panels in place. Here is how removal and reinstallation work, and why the order matters.
Schedule Your Roofing Inspection Today
Fill out the information below and we’ll reach out to complete your estimate as soon as possible!
Five stages of the job
Document
Photos of each panel, the racking and the roof under it before any work.
Remove the panels
Panels and rails come off in order.
Decide where panels sit
Before the work date, agree on a spot for the panels and who is responsible for them.
Repair or replace the roof
Damaged decking, shingles and flashing are fixed, with new flashing at each future mount.
Reinstall and seal
Rails and panels go back up and every attachment point is sealed.
Why Galena Park panels come down
Storms are the main reason. NOAA's Storm Prediction Center logged 23 hail reports within 10 miles of Galena Park from 2015 through 2024. Six were 1.75 inches or larger, in 2019, 2023 and 2024, and the largest was 2 inches on May 9, 2019. Hail that size can damage shingles beside and under an array, and the only way to repair them is to lift the panels.
Age is the second reason. Half of the homes in Galena Park were built before 1956 (U.S. Census Bureau, American Community Survey 2020-2024). If panels went onto a roof that was already well into its life, that roof will need replacing while the panels still work. Then they have to come off and go back on.
Common situations
Leak at a mount
Water gets in at an attachment point. The panels over it come off so the flashing can be redone.
Hail damage under the array
Bruised shingles under panels are repaired after removal. Coverage depends on your policy.
Full roof replacement
All panels come off, the new roof goes on and the system is reinstalled.
Decking problems
Soft spots found during roof work are fixed before the mounts go back.
Timing the roof and the panels
The best moment to deal with an aging roof under solar is when the panels have to come off anyway. If a storm forces removal on a roof that is already old, replacing the whole roof at once means paying for removal only one time.
If the roof is younger and the damage is in one area, a targeted repair under a few panels may be all you need. A careful inspection with photos tells you which case you are in. Our article on what happens if you wait too long to replace a roof explains the cost of putting it off.
What to ask before you hire
Will one company handle both the roof and the panels?
How will panels be stored and protected on site?
Will each mount get new flashing on the new roof?
How is the system checked after reinstallation?
What does the written estimate include?
Roof and solar under one plan
GemSco does roofing and solar panel removal and reinstallation, so the roof work and the panels move on one schedule. We are family owned, fully licensed and insured, with 20+ years of experience, and estimates are free. If hail is involved, start with an inspection and photos, then read about roof insurance claims. See our solar panel removal and reinstallation service, Galena Park roof repair or our Galena Park page.
Frequently Asked Questions
Can I leave the panels on and repair around them?
Only if the damage is clearly outside the array. Shingles, flashing and decking under panels cannot be repaired properly with the panels in place. Leaving damage hidden under the array often leads to a bigger leak later, so removal is usually the safer choice.
Is panel removal part of a hail claim?
It depends on your policy and your insurance company. Some policies treat removal and reinstallation as part of the roof repair, others handle it differently. Document the damage, share a written estimate that lists the panel work and ask your adjuster how it is treated.
Should I replace an old roof when the panels come off?
If the roof under the panels is near the end of its life, replacing it now usually makes sense. Panels would have to come off again for a replacement in a few years. On a younger roof with limited damage, a repair can be enough.
More Roofing Help in Galena Park
Roofing in Galena Park, TX
City overviewRoof Repair in Galena Park
Learn MoreRoof Replacement in Galena Park
Learn MoreStorm & Hail Damage in Galena Park
Learn MoreRoof Inspection in Galena Park
Learn MoreCommercial Roofing in Galena Park
Learn MoreGutters in Galena Park
Learn MoreSolar Panel Installation in Galena Park
Learn MoreSolar Removal & Reinstall Near Galena Park
Solar Removal & Reinstall in Jacinto City, TX
Learn MoreSolar Removal & Reinstall in South Houston, TX
Learn MoreSolar Removal & Reinstall in Pasadena, TX
Learn MoreSolar Removal & Reinstall in Deer Park, TX
Learn MoreSolar Removal & Reinstall in Houston, TX
Learn MoreSolar Removal & Reinstall in La Porte, TX
Learn MoreWe’re Here to Help!
GemSco Roofing & Solar serves Houston, DFW, Austin, San Antonio and surrounding areas. We’re family owned and fully licensed and insured.