Removing and Reinstalling Solar Panels in Fulshear
When the roof under your panels needs work, the panels have to come off first. Here is how that goes and what to plan for.
Schedule Your Roofing Inspection Today
Fill out the information below and we’ll reach out to complete your estimate as soon as possible!
When panels have to come off
Panels cover part of the roof, so any repair or replacement under them means removing them first. The most common trigger is storm damage. Others are leaks around mounts, worn shingles near the end of their life and a roof replacement planned for the whole house.
Moving panels is careful work. Each panel, rail and mount has to be taken down and put back so the system works and every roof penetration stays sealed.
Leaving roof damage under panels is risky. Water that gets in at a cracked shingle or a loose mount can run along the decking for a long time before it shows in a ceiling. By then the repair is bigger than it needed to be. Read why roof damage may not cause an immediate leak.
Fulshear facts worth knowing
NOAA's Storm Prediction Center logged 10 hail reports within 10 miles of Fulshear from 2015 through 2024.
Two of those reports were 1.75 inches or larger, both in 2019.
The largest hailstone, 2.5 inches, was reported on May 9, 2019. Hail that size can damage the shingles around and under panels.
Half of the homes in Fulshear were built before 2016 (U.S. Census Bureau, American Community Survey 2020-2024). Many roofs with panels are still young, so removal is more often about storm damage than age.
With 90 percent of homes owner occupied, the owner usually manages both the roof and the solar system.
The process from start to finish
Inspect and document
Photos of the panels, mounts and roof before anything is moved.
Remove the panels
Panels and racking come off in order.
Settle panel storage
Decide ahead of time where the panels will be kept off the roof and who looks after them.
Fix the roof
Repair or replacement under the array, with new flashing at each mount point.
Reinstall
Racking and panels go back on and every penetration is sealed.
Final check
Photos of the finished work go into your records.
Questions to settle before work starts
Who handles the roof?
One company for both roof and panels keeps responsibility in one place.
What about insurance?
If hail caused the damage, ask your insurer how panel removal is treated. Coverage depends on your policy. See roof insurance claims.
How long will panels be off?
It depends on the roof work. Ask for an estimate in writing.
Will the mounts be reused?
Ask whether new flashing goes in at each attachment. Reusing old seals on a new roof is a common source of leaks.
Who tests the system?
Ask how the system will be checked after reinstallation, and get it in writing.
One crew, one plan
GemSco does roofing and solar panel removal and reinstallation, so both parts of the job fit in one plan. We are family owned, fully licensed and insured, and estimates are free. See our solar panel removal and reinstallation service, hail damage roof repair in Fulshear or our Fulshear page.
Ask for the full plan in writing before the first panel comes down, including the roof scope and the order of the work.
Frequently Asked Questions
Do all the panels have to come off for a small repair?
Not always. If the damage is in one area, sometimes only the panels over that section need to move. A roofer will check the roof first and explain how many panels must come off to reach the damaged area safely.
Can my panels be damaged during removal?
Any handling carries some risk, which is why documentation matters. Photos before removal record the condition of each panel. Careful removal, padded storage and reinstalling in order reduce the risk. Ask how panels will be stored while the roof work is done.
Is this a good time to replace the whole roof?
If the roof under the panels is worn or damaged across many slopes, yes. Panels must come off either way, so replacing the roof now avoids paying for another removal later. If the roof is young and damage is limited, a repair is usually enough.
More Roofing Help in Fulshear
Roofing in Fulshear, TX
City overviewRoof Repair in Fulshear
Learn MoreRoof Replacement in Fulshear
Learn MoreStorm & Hail Damage in Fulshear
Learn MoreRoof Inspection in Fulshear
Learn MoreCommercial Roofing in Fulshear
Learn MoreGutters in Fulshear
Learn MoreSolar Panel Installation in Fulshear
Learn MoreSolar Removal & Reinstall Near Fulshear
Solar Removal & Reinstall in Katy, TX
Learn MoreSolar Removal & Reinstall in Rosenberg, TX
Learn MoreSolar Removal & Reinstall in Richmond, TX
Learn MoreSolar Removal & Reinstall in Sugar Land, TX
Learn MoreSolar Removal & Reinstall in Meadows Place, TX
Learn MoreSolar Removal & Reinstall in Stafford, TX
Learn MoreWe’re Here to Help!
GemSco Roofing & Solar serves Houston, DFW, Austin, San Antonio and surrounding areas. We’re family owned and fully licensed and insured.