Glenn Heights Solar Panel Removal and Reinstallation for Roof Work
Hail and age do not stop at the edge of a solar array. When the roof under it needs attention, the panels have to come off and go back on with care.
Schedule Your Roofing Inspection Today
Fill out the information below and we’ll reach out to complete your estimate as soon as possible!
Signs the roof under your panels needs work
A ceiling stain below the area covered by the array.
Shingle pieces or granules collecting under the panels or in the gutters below them.
Dents on panel frames, rails or nearby vents after a storm.
Leaks near where rails attach to the roof.
A roof that is near the end of its life, whether or not it leaks yet.
Glenn Heights roofs under solar
Half of the homes in Glenn Heights were built before 2004 (U.S. Census Bureau, American Community Survey 2020-2024). Arrays added to those homes often sit on original roofs that are now around 22 years old. When those roofs need replacing, the panels have to come off first.
Recent hail adds urgency. NOAA's Storm Prediction Center logged 95 hail reports within 10 miles of Glenn Heights from 2015 through 2024, with 19 of them 1.75 inches or larger. Large hail came in 2017, 2021, 2023 and 2024. The 4-inch stone on June 12, 2023 was the largest. Shingles under the array can be bruised even if the glass survived, and that damage cannot be checked with the panels in place.
With about 78 percent of occupied homes owner-occupied (ACS 2020-2024), most owners here deal with this decision directly.
How we take down and put back an array
Record the setup
Photos of the layout, wiring and mounts before anything is touched.
Lift off
Panels and rails are removed.
Roof repair or replacement
We fix the roof, including decking and flashing, and prepare new mount points.
Reinstall
The array goes back, each mount is sealed and the roof around the array is checked.
Plan ahead for these
System documents
Some solar systems have rules about who may remove panels. Check yours before work starts.
Insurance
If hail damaged the roof or panels, coverage depends on your policy. GemSco documents both with photos and a written estimate.
Weather
Dry weather makes the job smoother. A temporary cover can protect an active leak until work begins.
Taking care of the panels while they are down
Agree before the job where panels will lie flat and protected, so they are not stepped on or blown around. Wiring is labeled so it goes back the way it came out. Before reinstalling, we look over each panel for cracked glass or bent frames and tell you if anything looks damaged, so it can be dealt with before it goes back up.
Rails and clamps get the same check. Worn or corroded hardware is pointed out before reuse, since a bad clamp on a new roof can create the very leak you just paid to stop.
Why use one company for both
When one crew removes the panels and a different one does the roof, gaps in responsibility show up at the mounts. GemSco handles roofing and solar panel removal and reinstallation, so the same team answers for both. See our hail damage roof repair page for Glenn Heights, our general solar removal and reinstallation service and our Glenn Heights page. Estimates are free.
Frequently Asked Questions
Can a leak under the panels be fixed without removing them?
Rarely. If the leak is at the edge of the array, a few panels may be enough. Most leaks under an array need the panels above them taken off so the shingles, underlayment and mount flashing can be repaired properly.
Will the panels go back in the same place?
Usually, yes. Sometimes new flashing, vents or decking repairs mean a mount has to move slightly, or a rafter in the old spot turns out to be damaged. If anything about the layout needs to change, we explain it and show you why before the array goes back on the roof.
Should I replace the roof now if it still has some life left?
If it is close to the end of its life, replacing it while the panels are already off can save a second removal later. If it still has many good years, a repair may make sense. An inspection helps you weigh the two with real information.
More Roofing Help in Glenn Heights
Roofing in Glenn Heights, TX
City overviewRoof Repair in Glenn Heights
Learn MoreRoof Replacement in Glenn Heights
Learn MoreStorm & Hail Damage in Glenn Heights
Learn MoreRoof Inspection in Glenn Heights
Learn MoreCommercial Roofing in Glenn Heights
Learn MoreGutters in Glenn Heights
Learn MoreSolar Panel Installation in Glenn Heights
Learn MoreSolar Removal & Reinstall Near Glenn Heights
Solar Removal & Reinstall in DeSoto, TX
Learn MoreSolar Removal & Reinstall in Red Oak, TX
Learn MoreSolar Removal & Reinstall in Lancaster, TX
Learn MoreSolar Removal & Reinstall in Cedar Hill, TX
Learn MoreSolar Removal & Reinstall in Duncanville, TX
Learn MoreSolar Removal & Reinstall in Midlothian, TX
Learn MoreWe’re Here to Help!
GemSco Roofing & Solar serves Houston, DFW, Austin, San Antonio and surrounding areas. We’re family owned and fully licensed and insured.