Freeport, TX Solar Panel Removal and Reinstallation for Roof Work
When the roof under a solar array needs repair or replacement, the panels have to come off. Here is how that should go on a coastal home.
Schedule Your Roofing Inspection Today
Fill out the information below and we’ll reach out to complete your estimate as soon as possible!
How the job works
Inspect
Check the roof around and under the array, the attic and every mount.
Write it up
One estimate covering removal, roof work and reinstallation, so nothing falls between two contractors.
Document the system
Photos and labels for each panel and connection.
Remove with care
Take down panels and racking in order.
Roof work
Repair or replace the roof, including deck and underlayment as needed.
Reinstall
Reset mounts in solid rafters with new flashing, then put the panels back.
Check
Review the array and the roof around it after the job, and look in the attic after the first heavy rain.
Why Freeport owners need this
Age is the most common reason. Half of the homes in Freeport were built before 1969 (U.S. Census Bureau, American Community Survey 2020-2024). If panels went onto a roof that was already partway through its life, the shingles under them may wear out well before the array does.
Wind is the other. Brazoria County is entirely within the TWIA catastrophe area. A strong storm can lift shingles at the edges of an array, loosen flashing at mounts or drive rain under the panels. When the roof under the array is damaged, the panels must come off to fix it properly. Patching around the rails leaves damaged shingles under the array, and those are the hardest spots to reach later.
Hail plays a smaller role here: NOAA's Storm Prediction Center logged 3 hail reports within 10 miles of Freeport from 2015 through 2024, the largest 1.5 inches on April 17, 2015.
Warning signs under an array
Ceiling stains near the area under the panels.
Shingles lifted or missing at the edges of the array.
Rust stains or loose flashing at mounts.
Damp or stained decking visible from the attic.
A roof that is near the end of its life everywhere else.
Granules or bits of shingle collecting in the gutters below the panels.
Leaves and debris trapped under the array, which hold moisture against the roof.
Before you book
Paperwork
Gather the original installation documents if you have them.
Insurance
If storm damage is involved, read your homeowners and wind policies. See roof insurance claims.
Windstorm rules
Roof work in the catastrophe area may need windstorm certification. Ask how it will be handled.
Timing
Avoid the heart of storm season if the work can wait.
Storage space
Plan where the panels will sit on the property while the roof is open, away from traffic and falling debris.
One team for the roof and the panels
Having the same team remove the panels, do the roof and put them back avoids gaps in responsibility if a leak shows up later. GemSco handles solar panel removal and reinstallation along with roof replacement in Freeport and roof repair in Freeport.
Read what happens if you wait too long to replace a roof if you are on the fence. Estimates are free. Learn more on our solar panel removal and reinstallation page.
Frequently Asked Questions
Can the roof under my panels be fixed without removing them?
Small repairs at the edges of an array can sometimes be done in place. Damage under the panels, a leak at a mount or a full replacement means they have to come off. Trying to work around them risks a poor repair. A roofer will tell you which case applies.
Should I replace the roof while the panels are off?
If the roof is older, it often makes sense. Paying to remove and reinstall panels twice in a few years costs more than doing the roof once. If the roof is newer and only one area is damaged, a repair under the array may be enough.
When is the best time of year for this work in Freeport?
If the work can wait, schedule it outside the busiest part of storm season so the roof is not open when a system moves in. Leaks or storm damage should not wait. A temporary cover can protect the roof until the full job is scheduled.
More Roofing Help in Freeport
Roofing in Freeport, TX
City overviewRoof Repair in Freeport
Learn MoreRoof Replacement in Freeport
Learn MoreStorm & Hail Damage in Freeport
Learn MoreRoof Inspection in Freeport
Learn MoreCommercial Roofing in Freeport
Learn MoreGutters in Freeport
Learn MoreSolar Panel Installation in Freeport
Learn MoreSolar Removal & Reinstall Near Freeport
Solar Removal & Reinstall in Lake Jackson, TX
Learn MoreSolar Removal & Reinstall in Brazoria, TX
Learn MoreSolar Removal & Reinstall in Angleton, TX
Learn MoreSolar Removal & Reinstall in Galveston, TX
Learn MoreSolar Removal & Reinstall in Alvin, TX
Learn MoreSolar Removal & Reinstall in Manvel, TX
Learn MoreWe’re Here to Help!
GemSco Roofing & Solar serves Houston, DFW, Austin, San Antonio and surrounding areas. We’re family owned and fully licensed and insured.