Wylie, TX Solar Panel Removal and Reinstallation for Roof Work
A damaged or aging roof under solar panels cannot be fixed properly with the array in the way. Here is how the panels come off, the roof gets done and everything goes back.
Schedule Your Roofing Inspection Today
Fill out the information below and we’ll reach out to complete your estimate as soon as possible!
Why the panels have to come off
Roof replacement
Shingles under the array must be removed and replaced like the rest of the roof.
Storm damage
Hail can break shingles beneath the panels where no one can see them.
Leaks at mounts
Failed flashing at an attachment point lets water into the decking.
Decking repairs
Soft or rotted boards under the array need direct access.
What drives this work in Wylie
Storms are the main driver. NOAA's Storm Prediction Center logged 32 hail reports of 1.75 inches or larger within 10 miles of Wylie from 2015 through 2024, and the largest, 5.25 inches, fell on April 11, 2016. A roof under an array can be damaged even when the panels look intact, and the only way to fix it properly is from the deck up.
Roof age adds to it. Half of the homes in Wylie were built before 2006 (U.S. Census Bureau, American Community Survey 2020-2024), so many roofs are around 20 years old. Arrays installed on those roofs a few years ago may now be sitting on shingles that are ready for replacement. See roof replacement in Wylie for the signs.
Leaks are the third trigger. A mount that was not flashed well, or flashing that has aged, can let water reach the decking right under the panels. Because the array hides that area, the first sign is often a stain on a ceiling or a damp spot in the attic, and finding the source usually means lifting at least part of the array.
Before the work starts
Photograph each panel and the array layout.
Note any cracks or damage on panels before removal.
Decide whether the roof needs a repair or a full replacement while the panels are off.
Ask how the panels will be stored during the roof work.
If a storm caused the damage, check how your policy treats removal and reinstallation. See roof insurance claims.
How the job runs
Remove
Panels and racking are taken down.
Open the roof
Shingles and underlayment under the array come off and the deck is checked.
Rebuild
Damaged decking is replaced, new underlayment and flashing are installed, and new shingles go on.
Flash the mounts
Each attachment point gets new flashing on the new roof.
Reinstall
Racking and panels go back in their original layout.
One team for roof and panels
When the same company removes the panels, does the roof and puts the array back, there is no question about who owns the roof around the mounts. GemSco offers solar panel removal and reinstallation together with roof repair and replacement. Estimates are free. Learn more on our solar panel removal and reinstallation page or the Wylie page.
While the panels are off, the roof under them is fully open for the first time since the array went up. That is the moment to replace soft boards, put down new underlayment and set fresh flashing, because the next chance to reach that area may be many years away. A roof inspection in Wylie before the job tells you how much of that to expect.
Frequently Asked Questions
Do all the panels need to come off for a repair?
Not always. If the damage is in a small area near the edge of the array, removing a few panels may be enough. For a full roof replacement, the whole array comes off. An inspection shows which case you are in.
Can I leave the panels off for a while?
It is possible, but most owners want them back as soon as the roof is done. Ask how long the roof work is expected to take and plan storage for that time. Keeping panels safe and dry while they are off is part of the job.
Should I replace the roof if it is around 20 years old and the panels are coming off anyway?
Often that is the smart move. Removing and reinstalling the array has a real cost. If the roof will need replacing in the next few years, doing it now avoids paying for a second removal later. An inspection helps you weigh that choice.
More Roofing Help in Wylie
Roofing in Wylie, TX
City overviewRoof Repair in Wylie
Learn MoreRoof Replacement in Wylie
Learn MoreStorm & Hail Damage in Wylie
Learn MoreRoof Inspection in Wylie
Learn MoreCommercial Roofing in Wylie
Learn MoreGutters in Wylie
Learn MoreSolar Panel Installation in Wylie
Learn MoreSolar Removal & Reinstall Near Wylie
Solar Removal & Reinstall in Murphy, TX
Learn MoreSolar Removal & Reinstall in Sachse, TX
Learn MoreSolar Removal & Reinstall in Rowlett, TX
Learn MoreSolar Removal & Reinstall in Rockwall, TX
Learn MoreSolar Removal & Reinstall in Garland, TX
Learn MoreSolar Removal & Reinstall in Richardson, TX
Learn MoreWe’re Here to Help!
GemSco Roofing & Solar serves Houston, DFW, Austin, San Antonio and surrounding areas. We’re family owned and fully licensed and insured.