Schertz Solar Panel Removal and Reinstallation for Roof Work
An aging roof does not stop aging because panels are on it. When it needs work, the panels come off first and go back once the roof is ready.
Schedule Your Roofing Inspection Today
Fill out the information below and we’ll reach out to complete your estimate as soon as possible!
Common reasons to remove panels
Roof replacement
The roof under the array has reached the end of its life.
Leaks near mounts
Water traced to flashing at mount points or to shingles under the panels.
Storm damage
Hail or wind damage on shingles hidden by the array.
Flashing or decking repair
Work that cannot be done properly with panels in the way.
Older racking
Rails, clamps and wiring that have aged in the sun are looked over before they go back on a new roof.
Why it comes up in Schertz
Half of the homes in Schertz were built before 2002 (U.S. Census Bureau, American Community Survey 2020-2024). Many solar systems here were installed on roofs that already had years of wear. Those roofs are now about 24 years old, and owners are finding that replacement means dealing with the panels first.
Storms add to it. NOAA's Storm Prediction Center logged 30 hail reports within 10 miles of Schertz from 2015 through 2024. Only 1 was 1.75 inches or larger, a 2-inch stone on April 12, 2016, but smaller hail on brittle shingles still causes damage, and the shingles under an array are the hardest to check.
How the job works
Inspect and document
We check the roof and array and take photos of existing conditions.
Remove the system
Panels and racking are taken down, labeled and stored safely.
Do the roof work
Repair or replacement on a fully exposed roof, including decking and flashing at every mount point.
Reinstall and seal
Mounts are refastened and flashed, and the panels go back.
Get these in writing
A free estimate that lists the panel work and the roof work separately.
The roof material and underlayment being installed.
How mount points will be flashed on the new roof.
Before-and-after photos of the roof and array.
If storm damage is involved, notes you can share with your insurer. Coverage depends on your policy and insurance company.
Who is responsible for the roof at the mount points after the panels are back.
Timing and weather
The system is off while the panels are down, so the goal is to keep that window short. Removal, roof work and reinstallation should follow one another on a clear schedule. Planning around the weather helps as well, since an open roof is easier to protect during calm stretches. Our article on the best time of year to replace a roof in Texas covers the trade-offs.
If a storm started the project, take dated photos of the array and the roof before anything is removed. That record shows what the storm did.
Make the most of the panels being off
About 78 percent of occupied homes in Schertz are owner-occupied (U.S. Census Bureau, ACS 2020-2024), so most owners can plan this as one project. If the roof is old, replace it while the panels are down rather than patching and paying for removal again later. Ask about shingles tested to UL 2218 Class 4.
See roof replacement in Schertz, roof repair in Schertz and our solar panel removal and reinstallation service. Before you start, read things to do before replacing your roof.
Frequently Asked Questions
Do all the panels have to come off for a roof replacement?
For a full replacement, yes. The whole roof surface has to be exposed so the old layers can be removed and new underlayment, flashing and shingles installed. For a small repair near the edge of an array, removing only a few panels may be enough.
How can I tell if the roof under my panels is damaged?
Look for attic stains directly under the array, granules in the gutters below it and dents elsewhere on the roof after storms. Since the shingles under the panels cannot be seen from the ground, an inspection with photos is the reliable way to know.
Is this a good time to switch roof materials?
It can be. With the panels off and the old roof removed, you can choose a different material, such as metal or impact-rated shingles. The mounting method for the panels may change with the material, so plan both together in the written estimate.
More Roofing Help in Schertz
Roofing in Schertz, TX
City overviewRoof Repair in Schertz
Learn MoreRoof Replacement in Schertz
Learn MoreStorm & Hail Damage in Schertz
Learn MoreRoof Inspection in Schertz
Learn MoreCommercial Roofing in Schertz
Learn MoreGutters in Schertz
Learn MoreSolar Panel Installation in Schertz
Learn MoreSolar Removal & Reinstall Near Schertz
We’re Here to Help!
GemSco Roofing & Solar serves Houston, DFW, Austin, San Antonio and surrounding areas. We’re family owned and fully licensed and insured.